Bajaj-electricals DB30 Bedienungsanleitung

Always wear a helmet; It could save your Life!Please obtain, review, and follow provincial / municipal government acts and regulations pertaining to o

7SAFETYLOCATION OF LABELS6-7-769-988-

8SPECIFICATIONSDescription DataOverall length 1295mm (50.98 inches)Overall width 640mm (25.20 inches)Overall height 860mm (33.86 inches)Wheelbase 935m

9Pull Start CordAir FilterGas TankFoot pegsThrottle handleOn/Off ButtonBrake CaliperFront WheelKick StandRear WheelSeat CushionHand brakeClutch coverD

10LEFT AND RIGHT HAND GRIP OPERATION ENGINE PULL CORD OPERATIONPulling in brake lever located on left hand grip will stop mini bike.Applying the ha

11FUEL AND FUEL VALVE OPERATIONFuel llingThe capacity of the fuel tank is 1.4L (.40 qt .) Unscrew the gas cap by turning it counter clockwise and ca

12 WARNINGFailing to inspect the Mini Bike before operating could be hazardous. Failing to perform proper maintenance could also be hazardous.Failing

131. Ensure there is fuel in fuel tank and oil in crank case.2. Set fuel valve lever to “ON” position3. Place choke lever to “ON” position4. Start

14CHECKING THE OILCheck engine oil each time prior to operating mini bike.The oil level should be between upper and lower lines of oil gauge.1. Set t

15CHANGING THE OIL1. Remove the “Screw Plug” located at the bottom of the engine and let the oil drain into an approved collection container. DO NOT

16CHECKING & CLEANING THE AIR FILTER1. Locate Air Filter Box at rear of engine 2. Remove air lter cover by unscrewing phillips head screw3.

iiCongratulations on your purchase of the BAJA INC. DB30 Mini Bike. Your Mini bike is warranted to be free of manufacturing defects in the material o

17ADJUSTING THE THROTTLE CABLEMake sure the throttle cable is adjusted properly. To adjust throttle cable, rotate adjustment nut located at the ha

18ADJUSTMENT OF REAR BRAKE1. The front brake hand grip should have free operating movement of 5-7mm (.2-3in.) . Adjust with free play adjustment b

19GREASING PROCEDURES TO THE DRIVING CHAIN1. Shut off the engine2. Add light amounts of machine oil or chain grease to the driving chain. (Too muc

20CLUTCH CLEANING AND MAINTENANCE After every 5 hour of use, your clutch will need cleaning and lubrication. If clutch becomes too dirty or has la

21VEHICLE WASHINGCleaning the vehicle regularly can slow down the color fading of its body and make it easier to check if there is any damage and any

22INSTRUCTIONS FOR STORAGEIf the vehicle is not going to be used for a long period of time, for example, in winter time, some steps should be taken to

23RESUMPTION OF SERVICE AFTER STORAGE1. Remove the covering and remove the wooden blocks used in storing the vehicle. Change the engine oil if the

24“*” means: This item of maintenance should be carried out at a service center. It may be also done by the user with reference to this manual provi

251. Fuel Valve OFF Move Fuel valve lever to ON. 2. Choke OPEN Move Choke Lever to CLOSED3. Out of fuel Refuel4. Bad fuel; engine stored without

26Engine SwitchTransistor MagnetoIgnition CoilSpark PlugB1B1ELECTRICAL SCHEMATIC

iiiThis manual should be considered as a permanent part of the vehicle and should remain with the vehicle when resold or otherwise transferred to a ne

27BAJA INC. – EMISSION CONTROL SYSTEM WARRANTYYOUR WARRANTY RIGHTS AND OBLIGATIONSThe emission control system warranty period for this vehicle begins

28Your emission control system warranty covers components whose failure would increase an engine’s emission, including electronic controls, fuel injec

29EMISSION CONTROL SYSTEM WARRANTYo Use of replacement parts or accessories not conforming to the original specications which adversely affect perfo

Baja, INC.P.O. Box 61150Phoenix, AZ 85082Tel: 602-443-9180Toll Free: 888-863-BAJA (2252)

1TABLE OF CONTENTSSAFETY ------------------------------------------------------- 2 Safe Operation ------------------------------------ 3 Safety

2Please read this manual and follow all instructions carefully. To emphasize the special information, the symbol and the words WARNING or CAUTION h

3SAFE OPERATIONRules for Safe Operation· A pre-operation check must be conducted, before starting the engine, insure safety, prevent mishaps, and dam

4· This user’s manual contains important safety and maintenance information. Read it carefully before riding. Failing to follow the warnings contain

5CAUTIONNever perform any unauthorized modications to this vehicle. Only use original replacement part which can be obtained through BAJA INC. 888-8

63142512345LOCATION OF LABELSSAFETY